NEUTRALITE SAFETY SOLUTION
SAFETY DATA SHEET
U.S. / CANADA VERSION – EFFECTIVE: 02/08/2016
Neutralite Safety Solution complies with OSHA’s standard for washing facilities in general industry, 29CFR 1910.141(d)(2)(iii)
A description of all 16 sections of the SDS, along with their contents, is presented below:
Section 1: Identification
This section identifies the chemical on the SDS as well as the recommended uses. It also provides the essential contact information of the supplier. The required information consists of:
Product Name: used on the label and any other common names or synonyms by which the substance is known.
NEUTRALITE SAFETY SOLUTION – NSS1000
(SDS) SAFETY DATA SHEET – US/ CANADA version – Effective 01/01/2016
Name, address, phone number of the manufacturer, importer, or other responsible party, and emergency phone number.
Force Field Technologies, Inc. Emergency phone number:
P.O. Box 5381 Jim Warren (817) 326-2775
Granbury, TX 76049
Recommended use of the chemical (e.g., a brief description of what it actually does, such as flame retardant) and any restrictions on use (including recommendations given by the supplier). 1
Apply Neutralite Spray to cement contaminated skin. Neutralite instantly buffers and neutralizes cement alkalis on contact. Independent laboratory tests also confirm that Neutralite spray can chemically reduce Hexavalent Chrome to undetectable levels, thereby minimizing risk of allergic reaction.
Directions: Spray bottle contains Neutralite Crystals. Fill bottle with clean water to activate. Wipe off excess cement and drench spray affected area. Rub in and allow to dry. Reapply periodically on exposure to insure continuous protection. Best results come from consistent daily use. Neutralite does not form a protective barrier. It decontaminates. Neutralite does promote healing, but is not a medicine. It simply and safely buffers and adjusts skin surface pH.
Section 2: Hazard(s) Identification
This section identifies the hazards of the chemical presented on the SDS and the appropriate warning information associated with those hazards. The required information consists of:
- Hazard Classification – NA
- Hazard statement(s) – NONE
- Pictograms – NONE
- Precautionary statement(s) – NONE
- Hazards not otherwise classified – NONE
- Unknown toxicity – NONE
Section 3: Composition/Information on Ingredients
This section identifies the ingredient(s) contained in the product indicated on the SDS, including impurities and stabilizing additives. This section includes information on substances, mixtures, and all chemicals where a trade secret is claimed. The required information consists of:
Chemical name) – MONO POTASSUIM PHOSPHATE
Common name and synonyms – MKP
(CAS) number- 7778-77-0 PROPREITARY
Impurities and stabilizing additives – NONE
Same information required for substances – NONE
The chemical name and concentration (i.e., exact percentage) of all ingredients which are classified as health hazards and are: NONE
Cut-off/ Concentration limits – 30%
Health risk below the cut-off/concentration limits – NONE
Concentration (exact percentages) of active ingredient – A TRADE SECRET
Chemicals where a trade secret is claimed
EXACT PERCENTAGE OF CONCENTRATION WITHHELD BECAUSE OF A TRADE SECRET.
Section 4: First-Aid Measures
EYES: Flush eyes with large amounts of water. If irritation occurs and persists seek medical attention.
SKIN: Wash with water.
INHALATION: Remove from exposure.
INGESTION: Rinse mouth and dilute stomach contents with water, or preferably with milk if available. Large doses may cause nausea, vomiting and diarrhea.
NOTES TO PHYSICIAN: Systemic oral toxicity is extremely rare and has consisted of acidosis and hypocalcemic tetany.
Section 5: Fire-Fighting Measures
EXTINGUISHING MEDIA: Product is noncombustible.
SPECIAL FIRE FIGHTING PROCEDURES: Not applicable.
DEGREE OF FIRE AND EXPLOSION HAZARD: NONE
HAZARDOUS DECOMPOSITION: NONE
Section 6: Accidental Release Measures
PROCEDURE FOR RELEASE OR SPILL: Material should be swept up for salvage or disposal.
WASTE DISPOSAL METHOD: This product does not present a danger of hazard for disposal. Except for food applications, salvage and return to container, process or recycle for other uses. May be disposed of in landfills according to applicable regulations.
Section 7: Handling and Storage
HANDLING: Animal studies and manufacturing experience indicate that exposure to the crystalline form of product may result in eye and skin irritation. In the event of contact, immediately flush eyes with water, and wash of skin.
Section 8: Exposure Controls/Personal Protection
OSHA exposure limits:
Substance: Not Applicable
OSHA PEL-TWA: Not Applicable
OSHA STEL: Not Applicable
OSHA Ceiling: Not Applicable
OSHA Skin designation: Not Applicable
ACGIH TLV-TWA: Not Applicable
ACGIH STEL: Not Applicable
ACGIH Ceiling: Not Applicable
ACGIH Skin designation: Not Applicable
Target organ effects: Not Applicable
Carcinogenic potential: Not Applicable
Regulated by OSHA: No
Listed on NTP report: No
IARC Group 1, 2A, @r: No
U.S. EPA requirements release reporting: Not Applicable
CALIFORNIA PROP 65 – NOT LISTED
RECOMMENDATION PROCEEDURE IN EVENT OF CONTACT:
EYES: Flush eyes with large amount of water. If irritation occurs and persists seek medial attention.
SKIN: Wash with water.
INHALATION: Remove from exposure.
INGESTION: Rinse mouth and dilute stomach contents with water, or preferably milk if available. Large dose may cause nausea, vomiting, and diarrhea.
NOTES TO PHYSICIANS: Systemic oral toxicity is extremely rare and has consisted of acidosis and hypocalcemic tetany.
Section 9: Physical and Chemical Properties
Melting/ Freezing point: -h20, 253c
Boiling point: Not Applicable
Vapor pressure: Not Applicable
Vapor density (air=1): Non-volatile
Appearance: White crystals
Specific gravity (H2O=1): Bulk Density 1.2
Solubility in H2O % by Wt: 20 @ 25c
% Volatile’s: Non-volatile
Evaporation rate (butyl acetate=1): Non-volatile
PH (as is): Not Applicable
Auto ignition temperature: Non-combustible
Flammable limits (upper): Not Applicable
Flammable limits (lower): Not Applicable
Explosive properties: None
Oxidizing properties: None
Solubility: Not Available
Fat solubility (Solvent – Oil)
Section 10: Stability and Reactivity
HAZARDOUS POLYMERIZATION: Will not occur
CONDITIONS TO AVOID: None
MATERIALS TO AVOID: None
MAJOR CONTAMINANTS THAT CONTRIBUTE TO INSTABILITY: None
HAZARDOUS DECOMPOSITION PRODUCTS: None
SENSITIVITY TO MECHANICAL IMPACT: None
SENSITIVITY TO STATIC DISCHARGE: None
(Degree of hazard: 0= No hazard / 4= Severe hazard)
Special hazard: None
Section 11: Toxicological Information
Eye Contact: Non-irritating to unwashed eyes. Non-irritating to washed eyes (Rabbit).
Source: FMC Study 186-927
Skin Contact: Non-irritating at 1-1/2% solution (2oz. Neutralite Crystals to 1 gallon water)
Source: Stillmeadow, INC. – Primary dermal irritation study in rabbits. EPA Guidelines No. 81-5 Study #3659-97
Human industrial experience has shown no significant inhalation hazard or skin irritation for low-level long term exposure.
Skin Absorption: No published data
Inhalation: No published data
Ingestion: No published data
Acute effects from overexposure: Moderate irritant to unwashed eyes and mild irritant to washed eyes by animal tests.
Chronic effects from overexposure: (Effects considered include: Sensitivities, Carcidgenicity, Tetratogenicity, Mutagenicity, Synergistic Products, and any medical conditions generally recognized as being aggravated by exposure)
Human industrial experience has shown no significant inhalation hazard or skin irritation for low-level long-term exposure.
Carcinogenic potential: None
Section 12: Ecological Information (non-mandatory)
Section 13: Disposal Considerations (non-mandatory)
Waste Disposal Method: This product does not present a danger of hazard for disposal. Except for food applications, salvage and return to container, process or recycle for other uses. May be disposed of in landfills according to applicable regulations.
Section 14: Transport Information (non-mandatory)
D.O.T. proper shipping name: None. Not regulated
IATA: None. Not regulated
IMDG: None. Not regulated
D.O.T. Classification: Not regulated
D.O.T. Labels: Not regulated
D.O.T. Marking: Not regulated
D.O.T. Placard: Not regulated
UN Number: None
Hazardous Substance / RO: Not listed.
49 STCC Number: None
Precautions to be taken in transportation: None
Other shipping information: None
Section 15: Regulatory Information (non-mandatory)
Substance: Not applicable
OSHA PEL-TWA: Not applicable
OSHA STEL: Not applicable
OSHA Ceiling: Not applicable
OSHA Skin designation: Not applicable
ACGIH TLV-TWA: Not applicable
ACGIH STEL: Not applicable
ACGIH Ceiling: Not applicable
ACHIG Skin designation: Not applicable
Target organ effects: Not applicable
Carcinogenic potential: Not applicable
Section 16: Other Information
Neutralite Safety Solution comes with a pre-measured amount of NSS Crystals in each bottle. Potable water is added to spray bottle to activate crystals.
Activated NSS Solution shelf life – 6 months
Dry/ inactivated NSS shelf live – 5 years